Pajero 4WD Club of Victoria Public Forum Pajero 4WD Club of Victoria Public Forum

Go Back   Pajero 4WD Club of Victoria Public Forum > General Information > Fuel and fuel systems

Fuel and fuel systems Petrol vs Diesel, LPG Conversions, premium fuels, and all that gas

Reply
 
Thread Tools Display Modes
  #1  
Old 02-06-19
rottweiler rottweiler is offline
Junior Member
 
Join Date: May 2019
Location: new zealand
Posts: 1
Angry Engine stalling

Hi guys I have a 2007 D I D Pajero exceed 3.2 diesel and while I’m driving the engine stops dead , today she did it 5 times she only does it if we are travelling slow . She doesn’t do it when you do 100klms . She had been serviced fuel filter done and suction control valve as well. Took her to Mitsubishi and they plugged A computer and no friggin fault code. Went to fuel pump specialist and they reakon there isn’t a problem with pump then took her to a auto electrician and they had no idea what it could be. When we restart her after engine dies we have to put foot on gas to get rev up as she didn’t want to idle. But on way home up hills no problem she seems to behave when under load. Not nice when b***h stops at roundabout and traffic lights a bit scary. If u have any ideas what could be wrong wud luv to hear from u as my hair is going grey with worry
I checked the air flow sensor and cleaned it and the egr valve no carbon build up found out it has a blanking plate on it.
today i did the fuel tank filter which was a real bugger to do, many many swear words i can tell you, i was muttering it bloodly better be blocked the filter but nope not at all, and same problem. by this time if i had TNT it would be toast.
when she goes to die we have no throttle its limp as nothing there.
it started up a dream but then it dies afer sometime a minute or 10 minutes.
any ideas welcome.
also put the 2 fuel hoses together to see if it still stalls and yep she did

Last edited by rottweiler; 02-06-19 at 05:25 PM.
Reply With Quote
  #2  
Old 02-06-19
old Jack's Avatar
old Jack old Jack is online now
Valued Member
 
Join Date: Jun 2011
Location: Adelaide
Posts: 6,855
Default

A possible causes as listed in the online Service Manual.

Wrong fuel used
Fuel contaminated with foreign matter
Injector leaking or clogged
Failed injector
Fuel injection learning failure
Fuel filter clogged
Fuel line leaking or clogged
Failed fuel pressure limiter valve
Failed fuel pressure sensor
Failed supply pump (suction control valve)
Failed supply pump correction learning
Failed exhaust gas recirculation system operation
Failed valve clearance adjustment
Failed engine-ECU
Compression pressure low
Air cleaner clogged

OJ.
__________________
2011 PB Base White Auto, Smartbar, Cooper STMaxx LT235/85R-16,TPMS, HR TB, 3 x Bushskinz, front +40mm Dobinson , rear +50mm EHDVR Lovells, Dobinson MT struts and shockers, Peddars 5899 cone springs, Windcheater rack, GME UHF, Custom alloy drawer system inc. 30lt Engel & 2 x 30 AH LiFePo batteries + elec controls, Tailgate hi-lift/long struts, Nightbreaker +130LB & Phillips +100 HB, Lightforce 20" single row driving beam LED lightbar, Scanguage II.
MM4x4 Auto Mate, Serial No 1 .
Reply With Quote
  #3  
Old 20-07-19
Peterng Peterng is offline
Valued Member
 
Join Date: Jun 2013
Location: Northern Rivers NSW
Posts: 642
Default

Typical dealership techs..no fault code..no problem..never bloody think outside the square...fools.
Ok..so at 100 Kph..no problem..purrs like a kitten..no stuttering, no real delay when you tramp the go peddle..good pickup.
Only problem when you are low speed and low revs puttering around town.
When it stops next time..safety permitting..lift the bonnet..check the manual fuel pump..if it is soft when first pushing down.. then gets hard, after a few pumps( sound like a movie I once saw)..you have air getting into the system..somewhere.. at low speed / revs..prior to getting to the injector pump. I hope that gives you something to work with..


Sent from my iPhone using Tapatalk
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
NG Pajero engine stalling when cold Wizard1990 Generation 1 Pajero 3 04-10-16 10:10 PM
LPG issues ... stalling engine, sticky throttle linc Fuel and fuel systems 2 30-06-10 11:49 AM
car stalling Powie1 Generation 3 Pajero 2 07-06-10 06:26 PM
NH v6 stalling when engine bay is hot BlueJ Generation 2 Pajero 10 20-02-10 09:54 PM
LPG and Stalling! What Happens? Mad Mac Fuel and fuel systems 5 23-04-08 06:01 PM


All times are GMT +10. The time now is 11:43 PM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2019, vBulletin Solutions, Inc.