Pajero 4WD Club of Victoria Public Forum Pajero 4WD Club of Victoria Public Forum

Go Back   Pajero 4WD Club of Victoria Public Forum > Vehicles > Challenger > PB -PC Challenger 2009 - 2014

PB -PC Challenger 2009 - 2014 Covering 2.5 HP diesel

Reply
 
Thread Tools Display Modes
  #1  
Old 12-06-19
Onyx Onyx is offline
Junior Member
 
Join Date: Mar 2015
Location: ACT
Posts: 28
Default Challenger v. 13 week road trip through WA - what do I need?

Hi all
Just after some advice before I head off on an extended road trip/holiday. We are taking 14 weeks off work, taking our 6 and 8 years boys from Canberra essentially direct to NW WA, then slowly making our way south down the GRR before turning left at Geraldton to head home. We leave around the 9th of July.

On the way we plan to stop at Finke gorge, Mataranka then Kununurra, Purnululu, GRR (inc side trips to Mitchell Falls, etc and possibly the Munja track), Broome, Cape Leveque, Karratha and the Burrup Peninsula, Karijini, Ningaloo, Quobba/Gnarloo and Shark Bay. Plans are flexible at this stage and we'll play it a little by ear although there are key things we want to do and see.

We'll towing a 2015 Cub Supamatic Drover, it'll be under the max weight of 1500kg for the whole trip, sometimes only just.

The Challenger is getting its 75,000 km service this week and a Brown and Davis LR tank fitted next. I'll be running 265/75 R16 Hankook Dynapro MTs with about 12,000km on them. The truck tows ok with these on, but its no rocket ship. The Cub will be running the same size tyres. The car is set up as per my signature, although it also has a set of draws in the back plus a 50L water tank and a Rhino pioneer platform on the roof.

With just under 4weeks to go, we are almost ready to go. Now I just need to work out what spares I should take. I'm no mechanic, but can do the basics if needed and have the tools. At this stage I was planning to take:
- radiator hoses and coolant concentrate
- intercooler hoses
- air, oil and fuel filters
- belts - which ones?
- spare rear shocks
- nuts, bolts and screws (an assortment inc. wheel nuts)
- elect wire and connectors
- zip ties and duct tap
- wheel bearing?

Anything else I should be taking?

I have a full recovery kit, compressor and tyre plug kit.

Any advice/suggestions welcome.

Thanks in advance,
John
__________________
MY14 PC Manual - XROX bar, Runva 11XP winch, OME suspension, Basha plates, diff breathers extended, MM tow bar, Safari snorkel, Triton GLX-R wheels and Toyo OPATII 265/65 R17, OEM wheels and Hankook Dynapro MT 265/75 R16 for fun.
Reply With Quote
  #2  
Old 12-06-19
littleriver's Avatar
littleriver littleriver is offline
Valued Member
 
Join Date: Jan 2013
Location: Queensland
Posts: 3,253
Default

Think you have it pretty well covered ...

Possibly consider a satellite phone .. if not to buy think you can hire one ...

...
__________________
2012 PB Challenger LS (Manual) - OZtec shocks front & rear with King Springs (lift 2 inch) , 22 inch front #plate light bar, roof racks & basket, Bridgestone Duelers 697 LT A/T,Dash cam, 2 way radio 80 channel, Ipod connected via glove box usb, Waeco cf50, Garmin gps (with topo), Opticoat + paint protection, Nilrust proofing, Roosystems Ecu Remap
Reply With Quote
  #3  
Old 12-06-19
BMN BMN is offline
Valued Member
 
Join Date: Jul 2010
Location: Perth WA
Posts: 549
Default

Sounds like an awesome trip very envious. Kit sounds good, just take p/steering, aircon, waterpump belts. Do a regular check of the p/steering hoses on route, make sure they are not loose. If space is issue don't bother with intercooler hose just spare clamps.

Can recommend Millstream in the Chichester National Park, south of karratha, for a camp. You can easily spend a few days/week in Kalbarri and would not bother with Geraldton. But hopefully your planning on heading east through Mount Magnet-Sandstone and Leonora/Gwalia is a must, your kids will love Gwalia ghost town. Kookynie, Niagra dam is a good camp and Lake ballard are all good spots as you head south through Menzie's to Kalgoorlie-home.
__________________
2010 PB LS Auto, 7seat, silver with lots of pinstripes, Dual batts, Toyo AT2, ARB roof rack, Rear storage/fridge, Bilstien/Kings
Reply With Quote
  #4  
Old 12-06-19
Pixie_au Pixie_au is offline
Member
 
Join Date: Apr 2019
Location: Queensland
Posts: 64
Default

I did a similar trip but from Brisbane. I wished I'd taken a spare spring for the trailer as the corrugations fatigued one side. Fortunately not too far out of borroloola when it happened but held me up for two days waiting for parts.
Reply With Quote
  #5  
Old 12-06-19
BMN BMN is offline
Valued Member
 
Join Date: Jul 2010
Location: Perth WA
Posts: 549
Default

Jumper leads, and i would run the ATs. Lot of blacktop for MTs
__________________
2010 PB LS Auto, 7seat, silver with lots of pinstripes, Dual batts, Toyo AT2, ARB roof rack, Rear storage/fridge, Bilstien/Kings
Reply With Quote
  #6  
Old 12-06-19
DID Dash DID Dash is offline
Member
 
Join Date: Aug 2016
Location: Australia
Posts: 185
Default

Would suggest getting your long range tank in ASAP and running a few tanks of fuel through it. Insist it is cleaned thoroughly before fitment. Check installation quality and reconfirm prior to setting off. Sadly, it is often the aftermarket gear that can let you down. Know this through 1st hand experience, all be it 20 years ago. Great trip you are planning. Enjoy.
__________________
17MY Pajero Sport, Factory Towbar, King Springs KCRS-23/Pedders 5899 Cones, 265/70R17 A/T's for the rough trips.
Reply With Quote
  #7  
Old 12-06-19
KevL KevL is offline
Member
 
Join Date: May 2015
Location: Murphys Creek
Posts: 103
Default

If it were me I wouldnít bother with most of those spares.
Most of the journey is well travelled busy areas. Inspect the vehicle daily. Stay on top of it.
Seeing as itís being serviced soon, get belts etc inspected and replaced then and there.
Things like intercooler hoses etc are as likely to fail as say a cv joint.
You canít carry everything.

Over the years Iíve carried so much useless stuff ď just in caseĒ. Waste of time and money.



Sent from my iPhone using Tapatalk
Reply With Quote
  #8  
Old 12-06-19
old Jack's Avatar
old Jack old Jack is online now
Valued Member
 
Join Date: Jun 2011
Location: Adelaide
Posts: 6,774
Default

I would be packing.
1.Brake/clutch/power steering fluid.
2. Fuses.
3. Scangauge/Ultragauge/Torque Pro to read and clear fault codes.
4. Extra spare tyre carcass for the car and camper so 2 full spares + 1 carcass.
5. Multimeter.

I would not bother with carrying.
1. Rear shockers.
2. Wheel bearings.

I would be doing camper maintenance and inspection before leaving.
More likely to have camper trailer issues than Challenger issues.
1. Wheel bearings check and service.
2. Brakes check and service.
3. Coupling check and service.
4. Suspension check and service.

I would be doing a test load ASAP and measuring the rear suspension ride height to see if the rear coils are up to the loads you want to carry. If you have a saggy rear then this is a cheap temporary fix, if you do not want to change coils, upgrade rubber cones or fit airbags.
https://www2.pajeroclub.com.au/forum...ad.php?t=32385


OJ.
__________________
2011 PB Base White Auto, Smartbar, Cooper STMaxx LT235/85R-16,TPMS, HR TB, 3 x Bushskinz, front +40mm Dobinson , rear +50mm EHDVR Lovells, Dobinson MT struts and shockers, Peddars 5899 cone springs, Windcheater rack, GME UHF, Custom alloy drawer system inc. 30lt Engel & 2 x 30 AH LiFePo batteries + elec controls, Tailgate hi-lift/long struts, Nightbreaker +130LB & Phillips +100 HB, Lightforce 20" single row driving beam LED lightbar, Scanguage II.
MM4x4 Auto Mate, Serial No 1 .
Reply With Quote
  #9  
Old 12-06-19
nj swb's Avatar
nj swb nj swb is offline
Resident
 
Join Date: Jun 2007
Location: Adelaide
Posts: 5,651
Default

Zip ties and duct tape are great for those things that move when they shouldn't.

What will you carry for those things that don't move when they should?
__________________
NT Platinum. DiD Auto with 265/70R17 Toyo MT, Lift, Lockers, Lockup Mate, 3.15 gears, LRA Aux tank, bullbar, winch, lights, lots of touring stuff. Flappy paddles. MMCS is gone!

Project: NJ SWB. 285/75R16 ST Maxx, 2" OME suspension, 2" body lift, ARB 110, 120l tank, bullbar, scratches, no major dents. Fully engineered in SA. NW DiD & auto in place - a long way to go....

Scorpro Explorer Box
Reply With Quote
  #10  
Old 13-06-19
Hatto's Avatar
Hatto Hatto is offline
Valued Member
 
Join Date: Nov 2013
Location: Mandurah WA
Posts: 1,193
Default

Oil filter is pointless in my opinion. Think about it like this. If you need to change the oil filter then you'll need to carry enough oil to fill the donk again. If you really need an oil change then the next town wont be that far away to have it done where you can get both oil and filter.
Fuel filter is a worthy spare as there is always a chance of picking up dodgy fuel. If this happens and you konk out once fuel is transferred from the aux tank in the middle of nowhere or something then bleeding the fuel system and replacing the fuel filter could get you going and get you to the next town/servo.
Air filter, definitely if you're travelling dirt roads.
Wheel bearings and shocks I wouldn't bother with. Just have it all checked before you go. If a shockie fails on the road, you'll still be able to drive albeit feeling a little sea sick. Same as a wheel bearing. If one gets noisy it should get you to the next town a well.
One very important thing to organize in my opinion is a comprehensive roadside assistance coverage. Read the fine print and make sure it covers all states etc etc. Because if there is a breakdown that stops you in your tracks, you'll need the peace of mind of having a plan. Providing you have phone service? Hire a sat phone if you're really worried.
__________________
Cheers, Hatto

2012 NW GLS Diesel Auto with:
ARB delux bar, full length Ocam ally roof rack with rear LED work light, dual batteries, DIY rear ally drawers with fridge slide, 2" lift oztec/kings, Polyairs, Kings awning 2.5 x 2.5m with LED strip light, pair of genr8 40w LED spot/flood driving lights, iron man 4x4 22" LED light bar, mounted thumper compressor, 70L water tank & 12v pump, 120w solar, LED interior lights, Boo Boo's bash plates, Safari snorkel and Grande mk lll 12000lb winch.
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
7 week trip up north WA sandgroper 123 Pajero Sport QE 2015 - 2019 9 16-08-16 08:00 PM
3-4 Week Trip in the South West efeinblatt Hot Spots: WA 11 04-12-15 09:58 AM
3 Week trip suggestions craka Bits and Pieces 6 23-10-15 02:51 PM
5 Week Kimberley Trip via Uluru/Tanami Weavey72 Trekking around Oz 9 23-08-13 11:42 AM
Picture of Paj -1 week trip out to Winton QLD Scottyboy Trekking around Oz 0 16-08-09 11:08 PM


All times are GMT +10. The time now is 03:24 PM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2019, vBulletin Solutions, Inc.